SJT | Scientific Journal of Technology
← Back to Volume 8, Issue 1

Study on the Influence Law of CO₂ Treatment on Emulsion Stability

Peiyu Lu, Shuxuan Jiang
Vol. 8, No. 1, pp. 71-76, 2026 DOI: 10.54691/2d8qff44 January 21, 2026
Download PDF
Abstract.The formation of water-in-oil (W/O) emulsions during crude oil extraction leads to increased pipeline load, higher energy consumption, and elevated demulsification costs. CO₂ flooding technology can significantly improve emulsion stability by altering oil/water interfacial properties. This study investigates the influence law of CO₂ on the stability of W/O emulsions through experimental and theoretical analyses. Using a pressurized emulsification device and a high-speed microscopic observation system, combined with the water separation rate method and micromorphological analysis, the demulsification mechanism of CO₂ was revealed. Experimental results show that as the CO₂ pressure increases from atmospheric pressure to 2 MPa, the demulsification rate increases and the interfacial tension decreases. High-speed microscopic observations indicate that the droplet coalescence process can be divided into four stages: contact, deformation, film rupture, and coalescence. A mathematical stability model incorporating a deformation coefficient, contact angle correction, and pressure coefficient was established. CO₂ destabilizes emulsions through a dual mechanism: reducing the oil-phase viscosity and weakening the interfacial film strength. This study provides an important theoretical basis for optimizing CO₂ flooding technology.
Keywords. Water-in-oil (W/O) Emulsion; CO₂; Demulsification Mechanism; Mathematical Model.
APA Citation Peiyu Lu, Shuxuan Jiang (2026). Study on the Influence Law of CO₂ Treatment on Emulsion Stability. Scientific Journal of Technology, 8(1), 71-76. https://doi.org/10.54691/2d8qff44

References

  1. ARNOLD K, STEWART M, LAKE L W. Petroleum engineering handbook: Vol. I. General engineering[M]. Richardson: Society of Petroleum Engineers, 2004.
  2. YOU J, ZHANG L, WANG Q. Emulsion formation mechanisms in crude oil transportation systems[J]. Energy & Fuels, 2019, 33(5): 3675-3683.
  3. BEEN J, SJÖBLOM J, KILPATRICK P K. Heavy oil emulsions: Challenges and solutions[J]. Energy & Fuels, 2012, 26(7): 4048-4066.
  4. ARNOLD K. Emulsion breaking in petroleum production[R]. Richardson: SPE, 2007: 15-18.
  5. SJÖBLOM J, JOHNSEN E E, WESTVIK A, et al. Water-in-crude oil emulsions: Stability and interfacial properties[J]. Colloids and Surfaces, 1990, 46(2): 127-139.
  6. LI X, LI Z, WU Z. CO2-induced destabilization of water-in-crude oil emulsions[J]. Fuel, 2017, 209: 535-542.
  7. PARK J, LEE H. Interfacial phenomena in CO2-flooded oil reservoirs[J]. Journal of Petroleum Science and Engineering, 2002, 33(1-3): 23-32.
  8. FATHINASAB M, AYATOLLAHI S. Experimental study of CO2 effect on heavy oil-water interfacial tension[J]. Journal of Molecular Liquids, 2018, 272: 808-815.
  9. TAO R, XU X, TANG Z. Viscosity reduction of heavy oil by CO2 and surfactant emulsification[J]. Energy & Fuels, 2008, 22(6): 3573-3579.
  10. POST S L, ABRAHAM M H. CO2-induced destabilization of emulsions at oil-water interfaces[J]. Langmuir, 2002, 18(22): 8447-8454.
  11. YANG D, TONTIWACHWUTHIKUL P, GU Y. Interfacial tension of CO2-brine systems under reservoir conditions[J]. Journal of Chemical & Engineering Data, 2005, 50(4): 1242-1249.
  12. ZAKI N, ABDEL-AAL H, AL-SAHHAF T. Asphaltene deposition during CO2 flooding: A proposed mechanism[J]. Petroleum Science and Technology, 2003, 21(9-10): 1439-1454.
  13. MOHAMMED M A, et al. Viscosity reduction mechanism of CO2-saturated crude oils[J]. Journal of Petroleum Science and Engineering, 2018, 166: 742-750.
  14. ROSMAN A. Emulsion stability in enhanced oil recovery[R]. SPE 6865, 1977.
  15. HEMMATI-SARAPARDEH A, AYATOLLAHI S, GHAZANFARI M H. Experimental investigation of interfacial tension in CO2-brine systems[J]. Journal of Chemical & Engineering Data, 2014, 59(1): 61-69.
  16. ZHANG Y, WEI B, LI X, et al. Microscale study of CO2-assisted emulsion destabilization[J]. Fuel, 2020, 270: 117562.
  17. LASHKARBOLOOKI M, RIAZI M, AYATOLLAHI S. Synergistic effects of CO2 and surfactants on interfacial tension[J]. Colloids and Surfaces A: Physicochemical and Engineering Aspects, 2018, 553: 356-364.
  18. SIMON R, GRAUE D J. Generalized correlations for predicting solubility and density of CO2 in crude oils[J]. Journal of Petroleum Technology, 1965, 17(1): 102-106.
  19. He L, Huang X, Luo X, et al. Numerical study on transient response of droplet deformation in a steady electric field[J]. Journal of Electrostatics, 2016, 82: 29-37.
  20. Sun Guangyu. An integrated device and method for measuring viscosity of pressurized gas-dissolving crude oil emulsification[P]. Chinese Patent: 106198316, 2016-12-07.